Research Article

Standardization of Single Super Phosphate Fertilizer Formulation for Various Hazara Rock Phosphates

Matiullah Khan1*, Humera Arif2, Muhammad Rasheed2, Motsim Billah3 and Shoaib Ahmad1

1Land Resources Research Institute, National Agriculture Research Centre Islamabad, Pakistan; 2Pir Mehr Ali Shah, Arid Agriculture University Rawalpindi University Rawalpindi, Pakistan; 3University of Haripur, Pakistan.

Received | November 26, 2019; Accepted | March 18, 2020; Published | August 01, 2020

*Correspondence | Matiullah Khan, Land Resources Research Institute, National Agriculture Research Centre Islamabad, Pakistan; Email: [email protected]

Citation | Khan, M., H. Arif, M. Rasheed, M. Billah and S. Ahmad. 2020. Standardization of single super phosphate fertilizer formulation for various Hazara rock phosphates. Pakistan Journal of Agricultural Research, 33(3): 637-642.

DOI | http://dx.doi.org/10.17582/journal.pjar/2020/33.3.637.642

Keywords | Formulation of SSP, Rock phosphate, Available phosphorus, Sulfuric acid

Introduction

Rock phosphate is basically tri-calcium phosphate having unavailable form of phosphorus (Brady, 1990; Das, 2005). Approximately 90% of rock phosphate are used principally in the manufacture of granular and liquid phosphate fertilizers (Rabchevsky, 1997). The world known rock phosphate reserves are more than 40 billion metric tons which may sustain the world P fertilizer requirements for more than hundred years. Almost 60% of the world phosphate is produced by the U.S, North Africa (Morocco and western Sahara) and china for phosphate-fertilizer industry. The share of U.S for rock phosphate production exceeds 28 % (IPNI, 2008). The phosphorus and other elements contents in a rock phosphate determine its grade. A high-grade rock phosphate is always desired for manufacturing of fertilizer. Generally, above 30% P2O5 content in a rock in accepted for further processing. Generally, impurities of (CaO, Al2O3, MgO, SiO2, Fe2O3 are found in a rock phosphate depending upon its origin (Chavarria et al., 1981). Iron and aluminum compounds can be tolerated to a specific point although they decrease the available P content in the product. Silica has generally no such adverse effect other than decreasing the overall P content in the rock phosphate. The increase in CaO content increasing the requirement of sulfuric acid for SSP reaction. The huge amount of sulfuric acid application not only decreases available P content but increases cost as well (Lessis et al., 2015). Chlorine content in rock phosphate up to 0.5 has no such adverse effect on preparation of phosphatic fertilizer especially single super phosphate. Single Super phosphate has the easiest procedure of preparation. According to Khan et al. (2012) if 100 kg of Hazara rock phosphate is treated with the commercial sulfuric acid of 50% dilution (volume /volume), after proper processing, it will yield n/2(where n=P2O5 content in the rock phosphate), while Fertilizer Manual, 1979 reported that for 100 kg rock phosphate, 20.15-liter sulfuric acid of 93% concentration+ 2.54-liter water is required.

Pakistani soils have less than 10 mg kg-1 extractable P content hence marked as P deficient (Memon, 2005; Rashid, 2005). Heavy doses of P-fertilizers application are therefore recommended to combat the deficiency and get better crop yield. Pakistan annually imports 1090 thousand nutrient tons of P-fertilizers against its requirement of 1279 (GOP, 2018). About 35.7 million nutrient tons RP deposits are present in Hazara Division, Pakistan. The total reserves have the potential to sustain annual production for 30 years, more than the country requires at the moment. (PMDC, 2006). A very minute amount of local reserves is utilized for SSP preparation. During the year 2014 only 15 nutrient tons SSP (14-18% P2O5) was prepared in the local industry (GOP, 2018). The least availability of P from these rock phosphates might be due to the inappropriate formula they are using for SSP preparation. The experiment was therefore conducted to revisit the formulation of SSP with specific reference to various major location of Hazara rock phosphate and formulate an accurate recipe for the manufacturer.

Materials and Methods

The laboratory experiment for determination of phosphorus availability from different types of rock phosphate was conducted under lab conditions at Land Resource Research Institute, NARC Islamabad during 2015-2016. Guldania, Kakul and Paswal are the three main areas in Hazara where rock phosphate reserves are found and excavated manually or by small machinery at various scattered locations. Three samples each of stock quality and superior quality were collected from each location of all the three areas. The on-spot quality assessment of these rocks was done using experience of the local persons involved in the business. The samples were ground at particle size 160 mash level. A representative sample of each area were prepared having ±30% P2O5 content. Initial analysis of the rock phosphate was conducted at Soil Chemistry Laboratory, National Agriculture Research Centre Islamabad. The total P content and solubility of these rock phosphates were determined as per standard procedure (Olsen and Sommers, 1982) and given in Table 1.

Table 1: Total P content of rock phosphates and their solubility.

The dilutions of sulfuric acid were prepared as per standard procedure. 03 Beakers of 2.5 liter were labelled as D-1(45%), D-2 (50%) and D-3 (55%). Dilution-1 (45%) was prepared by adding 1.375 liter of tap water and then added 1.125-liter sulfuric acid in D-1 beaker with the help of graduated cylinder (1.0 liter) slowly and steadily to minimize fume emission. For D-2 (50%) preparation, 1.25-liter tape water was put in the beaker followed by 1.25-liter sulfuric acid. Similarly, D-3 (55%) was prepared by adding 1.375-liter acid to 1.125-liter water in the respective beaker. All the solutions were retained overnight to cool them down to room temperature. Weighed 200 g sample of each rock phosphate (Guldania, Kakul and Paswal) in plastic bottle and reacted with the respective dilution and quantity of acid as per treatment plan. After the reaction, all the bottles were kept at room temperature for 90 days. Periodic analyses of the reacted rock phosphate were carried out for available P content (Soltanpour and Workman, 1985) and free acid content (Pakistan Standard, 1961).

Results and Discussions

Available P concentration after acidulation of rock phosphates

The reaction of rock phosphate (RP) and acid for preparation of single super phosphate generally proceeds in two stages; in the first stage, sulfuric acid reacts with rock phosphate to form phosphoric acid (H3PO4) and calcium sulfate (CaSO4) and in the second step; the H3PO4 reacts with more rock phosphate to form mono-calcium phosphate or Single Super Phosphate (SSP). The first stage completes rapidly while the second stage continues for several days or weeks (Fertilizer Manual, 1979). Hence, after acidulation with various concentrations of acid, the mixture was kept to complete both the reactions. The F-values for the main plot where Guldania, Kakul and Paswal rock phosphates (Day 15, Day 45 and Day 90) and subplot where various dilution and amount of sulfuric acid applied were compared (Table 2). The Statistical analysis indicated that the effect of main plot and sub-plot were highly significant (P≤0.01) for periodic availability of P in all the rock phosphate samples. The interaction between main plot where periodic available P content from RP and subplot where various dilutions of sulfuric acid were kept, was also highly significant (P≤0.01).

Table 2: F-Values of ANOVA for the effect of acid applied on Guldania, Kakul and Paswal.

Available P on day 15: The data averaged across the main-plot for comparison of sub-plots’ effect, showed highly significant variations in available P content from various acidulated RP on day 15 (Table 3). The results showed that the significantly highest (P≤0.01) P content of (12.06%) was recorded in treatment (T3) where RP was treated with sulfuric acid dilution 55%+0.60 L and 12.03% in treatment (T2) with sulfuric acid dilution 50%+0.60 L were statistically at par. Whereas treatment T4 gave the lowest P availability (10.82%) with sulphuric acid dilution 45% and the amount 0.55 L. The data averaged across the sub-plot for comparison of main plots’ effect where various acidulated rock phosphates showed that highest P availability of (12.14%) was recorded in Guldania samples followed by Kakul with (11.90%) having statistical difference and the lowest available P content was recorded in Paswal (10.75%), irrespective of the treatments. The interaction between sub-plot and main plot was highly significant (P≤0.01) showing highest P availability of (12.53%) in the treatment where rock phosphate of Guldania was treated with sulfuric acid dilution 50%+ 0.60 L. The lowest P availability (9.99%) was recorded in Paswal with sulphuric acid dilution 45% +0.55 L.

Available P on day 45: The data averaged across the main-plot for comparison of sub-plots’ effect showed highly significant variations in available P content for various RP on day 15 (Table 4). The results showed that significantly the highest (P≤0.01) P availability of (14.84%) was recorded in treatment (T2) where sulfuric acid dilution 50%+ amount 0.60 L and, followed by treatment (T3) with 14.83% where sulfuric acid dilution 55%+ amount 0.60 L were used, with no statistical difference. Whereas, treatment T4 gave the lowest P availability (13.63%) where sulphuric acid dilution 45% amount 0.55 L was applied. The data averaged across the sub-plot for comparison of main-plots’ effect where various rock phosphates showed that highest P availability of (15.05%) was recorded in Guldania samples, followed by Kakul with (14.63%) having statistical difference. The lowest P availability was recorded in Paswal (13.11%), irrespective of the treatments. The interaction between sub plot and main plot was highly significant (P≤0.01). The highest P availability of (15.58%) was recorded in the treatment where rock phosphate of Guldania was treated with sulfuric acid dilution 50% + amount 0.60 L, while the lowest P availability (12.33%) was recorded in Paswal with sulphuric acid dilution 50% and the amount 0.55 L (Fertilizer Manual, 1979).

Table 3: Release of P from various rock phosphates by different acid dilutions and quantity on day 15.

Table 4: Release of P from various rock phosphates by different acid dilutions and quantity on day 45.

Available P content on day 90: The data averaged across the main-plot for comparison of sub-plot’s effect showed highly significant variations in available P content for various RP on day 15 (Table 5). The results showed that significantly the highest (P≤0.01) P availability of (14.56%) was recorded in treatment (T3) where sulfuric acid dilution 55%+ amount 0.60 L and 14.53% was applied followed by treatment (T3) with sulfuric acid dilution 50%+ amount 0.60 L with no statistical difference. Whereas treatment T4 gave the lowest P availability (14.18 %) with sulphuric acid dilution 45% while the amount 0.55 L. The data averaged across the sub-plot for comparison of main-plot’s effect where various rock phosphates showed that highest P availability of (15.03 %) was recorded in Guldania samples followed by Kakul with (14.63%) having statistical difference while the lowest P availability was recorded in Paswal (12.43%) irrespective of the treatments. The interaction between sub plot and main plot was highly significant (P≤0.01) and the highest P availability of (15.61%) was recorded in the treatment where rock phosphate of Guldania was treated with sulfuric acid dilution 50% + amount 0.60 L. The lowest P availability (12.15%) was recorded in Paswal with sulfuric acid dilution 55%+ the amount 0.55 L (Fertilizer Manual, 1979).

Table 5: P Release from various rock phosphates by different acid dilutions and quantity on day 90.

Free acid content in an SSP is the indicator of its quality. The SSPs having more than 5% free acid content are hygroscopic in nature and makes crumbs while kept in open air. The free acid data recoded in this experiment proved that the free acid content was higher in the treatment where least P release was recoded either due to excessive acid application than the optimal does or lesser and more diluted (Fertilizer Manual, 1979). The free acid content ranged from 4.23% to 7.68% among the treatments (Table 6). The trend of free acid content showed that either higher or lower sulfuric acid application caused higher free acid content in prepared SSP on day 90, this might be due to excessive sulfuric acid application or weak acid. The weak acid might not react with rock phosphate to release P and remained as such in SSP.

Table 6: Free Acid Content in various SSP after reaction on day 90.

The time span effect on the P availability of various rock phosphates after acidulation process remained ascending up to day 90 (Figure 1). Guldania showed maximum P availability (12.14%) than Kakul (11.90%) and Paswal (10.79) at day 15. Similarly, Guldania gave more P availability (15.05%) than Kakul (14.63%) and Paswal (13.11%) at day 45. Guldania showed highest P availability (15.03%) than Kakul (14.63%) and Paswal (12.41%) at day 90. The overall P availability was very sharp up to day 15 where 76.02%-76.19% of the available P content was recorded in Guldania, Kakul and Paswal irrespective of acid application. Guldania superseded in P availability over Kakul and Paswal by releasing 89.71% and 97.98% increased P respectively at day 15. The P availability trend between day 15 to day 90 was increasing but the rate of increase was not as sharp as up to day 15. The increase in P availability between day 45 and day 90 remained constant. The results are in accordance with the findings of Anonymous (2004) and The Pakistan Mineral Development Corporation (2006).

Conclusions and Recommendations

The result of these experiments showed that all the three rock phosphates released maximum P at different acid formulations. It is concluded that;

• • Guldania area rock phosphate is more reactive than Kakul and Paswal. It results in comparatively more enriched SSP.
• • Phosphorus availability remains increasing, after reaction up to day 45.
• • The amount of dilution of sulfuric acid required for reacting 1kg rock phosphate to release maximum P containing SSP.

Acknowledgement

Research for Agricultural Development Program (RADP) Pakistan Agricultural Research (PARC) is gratefully acknowledged for financial support to conduct this research.

Author’s Contribution

Matiullah Khan: Implementation of experiment, lab and field work planning and supervision, assistance in write-up.

Humera Arif: Lab and field work, analyses of data, drafting paper.

Muhammad Rashid: Main supervisor of the study. Helped in planning, write-up and review of study.

Motsim Billah: Assisted in data analyses, lab analytical work and experiments layout.

Shoaib Ahmad: Assisted in data compilation, review of literature and an analyses planning.

Conflict of interest

The authors have declared no conflict of interest.

References

Anonymous. 2004. Investment oriented study on minerals and mineral based industries. Experts Advis. Cell, Minist. Ind. Prod., GoP. pp. 113-117.

Brady, N., 1990. The nature and properties of soils. 8th edition. Macmillan Publ. Co., Inc. New York.

Chavarria, J.M., 1981. Hand book on phosphate fertilizers. ISMA limited, 28 Rue Marbeuf 75008 Paris.

Das, K.D., 2005. Introductory soil science. 4th edition, Kalyani Publishers, New Dehli, India.

Fertilizer Manual. 1979. United Nations Industrial Development Organization (UNIDO) Vienna, Austria. International Fertilizer Development Centre (IFDC) Muscle Shoals, Alabama, USA.

GOP. 2018. Economic survey of Pakistan (2014). Minist. Food Agric. Fed. Bur. Stat., GoP, Islamabad.

IPNI. 2008. Assessment of soil phosphorus status and management of phosphatic fertilizers to optimize crop production. IPNI-TECDOC-1272. Vienna.

Khan, M., S. Ahmad, M. Sharif, M. Billah and M. Aslam. 2012. Formulation of single super phosphate fertilizer from rock phosphate of Hazara, Pakistan. Soil Environ. 31(1): 96-99.

Lassis, M., N. Dadda and R. Rahmnia. 2015. Dissolution of Djebel Onk phosphate ore using sulfuric acid. Environ. Nanotechnol. Monit. Manage. 4: 12-16. https://doi.org/10.1016/j.enmm.2015.03.002

Memon, K.S., 2005. Phosphorus requirement of Pakistani Soils in: Proc. XII Int. Forum Soil Taxonomy Agro Technol. Transfer I. Soil Survey of Pakistan, Lahore.

Olsen, S. R., and L. E. Sommers. 1982. Phosphorus. In A. L. Page (ed.), Methods of Soil Analysis, Agron. No. 9, part 2: Chemical and Microbiological Properties, 2nd ed., Am. Soc Madison Wisconsim. 403-430.

PMDC, 2006. Survey brief report on rock phosphate at Kakaul and Tarnwari. Islamabad. pp. 1-13.

Pakistan Standard, 1961. Specification for super phosphate fertilizer. Pakistan Standard Institution. 67: 4-6.

Rashid, A., 2005. Soil science. 3rd edition. National book foundation, Islamabad, Pakistan.

Rabchevsky, G.A., 1997. Phosphate rock. US Geological Survey (Ed.), Mineral. Commod. Summ. 1997: 124-125.

Soltanpour, P.N. and S. Workman. 1985. Modification of the NH4 HCO3‐DTPA soil test to omit carbon black 1. Commun. Soil Sci. Plant Anal., 10(11): 1411-1420. https://doi.org/10.1080/00103627909366996